1.中国航发沈阳黎明航空发动机有限责任公司,沈阳 110043
2.内蒙古科技大学材料与冶金学院,包头 014010
3.钢铁研究总院有限公司特殊钢研究院,北京 100081
梅飞强(1989—),男,硕士,工程师; E-mail: 563122861@qq.com
赵吉庆(1984—),男,博士,正高级工程师; E-mail: zhaojiqing@nercast.com
收稿:2024-02-23,
纸质出版:2024-07-30
移动端阅览
梅飞强,赵吉庆,闫磊等.1Cr16Co5Ni2MoWVNbN耐热钢球座模锻成型工艺模拟与试验验证[J].特殊钢,2024,45(04):131-138.
Mei Feiqiang,Zhao Jiqing,Yan Lei,et al.Simulation and Test Validation on Die forging Process of 1Cr16Co5Ni2MoWVNbN Heat-resistant Steel Ball seat[J].Special Steel,2024,45(04):131-138.
梅飞强,赵吉庆,闫磊等.1Cr16Co5Ni2MoWVNbN耐热钢球座模锻成型工艺模拟与试验验证[J].特殊钢,2024,45(04):131-138. DOI: 10.20057/j.1003-8620.2024-00037.
Mei Feiqiang,Zhao Jiqing,Yan Lei,et al.Simulation and Test Validation on Die forging Process of 1Cr16Co5Ni2MoWVNbN Heat-resistant Steel Ball seat[J].Special Steel,2024,45(04):131-138. DOI: 10.20057/j.1003-8620.2024-00037.
通过热压缩模拟实验研究了1Cr16Co5Ni2MoWVNbN耐热钢在热变形过程中的动态再结晶行为,通过Deform 3D有限元数值模拟研究了应变速率和坯料尺寸对1Cr16Co5Ni2MoWVNbN 耐热钢球座模锻成型工艺的影响。热压缩试验结果表明,1Cr16Co5Ni2MoWVNbN 耐热钢发生动态再结晶、混晶现象不明显的临界变形量约为20%,增大应变速率有利于在小变形量下,获得更加均匀的组织。数值模拟结果表明,随着应变速率提高,模锻件最小变形区域的等效应变与等效应力均增加,随着坯料直径增加,模锻件最小变形区的等效应变下降,等效应力先降低后提高。应变速率为0.1 s
-1
时,坯料直径
<math id="M1"><mi>ϕ</mi></math>
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501073&type=
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501070&type=
2.03200006
2.87866688
60 mm~
<math id="M2"><mi>ϕ</mi></math>
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501057&type=
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501055&type=
2.03200006
2.87866688
65 mm,最小变形区域工程应变可达到20%以上,且具有较好的锻造成型性。根据数值模拟结果,设计了直径
<math id="M3"><mi>ϕ</mi></math>
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501073&type=
https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=62501070&type=
2.03200006
2.87866688
60 mm、高度74 mm的坯料,以0.1 s
-1
的应变速率进行模锻验证试验,试制出的锻件成型好、组织与硬度均匀,验证了数值模拟结果的合理与可行性。
The dynamic recrystallization behavior of 1Cr16Co5Ni2MoWVNbN heat-resistant steel during thermal deformation was studied by thermal compression simulation experiments. The effects of strain rate and blank size on the die forging process of 1Cr16Co5Ni2MoWVNbN heat-resistant steel ball seat were studied by Deform 3D finite element numerica
l simulation. The results of thermal compression test showed that the critical deformation of 1Cr16Co5Ni2MoWVNbN heat-resistant steel was about 20% when full dynamic recrystallization happened and the phenomenon of mixed crystalline was not obvious. And increasing the strain rate was conducive to obtaining a more uniform structure under small deformation. The numerical simulation results showed that with the increase of the strain rate, the equivalent strain and equivalent stress in the minimum deformation area of the die forging increased. And With the increase of the diameter of the blank, the equivalent strain in the minimum deformation zone of the die forging decreased, and the equivalent stress decreased first and then increased. When the strain rate is 0.1 s
-1
, and the diameter of the blank is 60 mm - 65 mm, the engineering strain in the minimum deformation area can reach more than 20%, and it had good forging formability. According to the numerical simulation results, a blank size with diameter of 60 mm and height of 74 mm was designed to verifying the forming of the die forging with strain rate of 0.1 s
-1
. The forgings were well formed, uniform in structure and hardness, which verified the rationality and feasibility of the numerical simulation results.
李志 , 支敏学 , 刘天琦 , 等 . 新型超高强度高韧性马氏体沉淀硬化不锈钢的组织和力学性能初探 [J]. 航空材料学报 , 2000 , 20 ( 3 ): 1 - 5 .
张凯强 , 李激光 , 唐广波 . Nb和V对1Cr16Co5Ni2MoWVNbN钢中析出相影响的模拟计算 [J]. 钢铁研究学报 , 2018 , 30 ( 01 ): 54 - 58 .
粟枯 , 许日泽 , 刘侠夫 . 叶片精锻 [M]. 北京 : 国防工业出版社 , 1984 .
Zhan M , Liu Y , Yang H . Influence of the shape and position of the preform in the precision forging of a compressor blade [J]. Journal of Materials Processing Technology , 2002 , 120 ( 1 ) : 80 - 83 .
张亚伟 . 热轧高强钢回火温度场数值模拟研究 [D]. 上海 : 上海交通大学 , 2015 .
Zhu H L , Li S Y , Wang C R . Numerical simulation of temperature field of gears in quenching process [J]. Applied Mechanics and Materials , 2014 , 457 : 566 - 570 .
杜丽萍 , 龚志华 , 赵吉庆 , 等 . 9Cr3W3Co叶片钢的热变形行为研究 [J]. 特殊钢 , 2023 , 44 ( 5 ): 90 - 96 .
孙铁峰 , 李许明 , 宋玺玉 , 等 . 锻造工艺对1Cr16Co5Ni2MoWVNbN钢组织和性能的影响 [J]. 沈阳航空航天大学学报 , 2012 , 29 ( 3 ): 38 - 42 .
刘大海 , 陈劲东 , 柴浩瑞 , 等 . 基于DEFORM-3D的GH5188卡箍热模锻造过程数值模拟 [J]. 锻压技术 , 2022 , 47 ( 6 ): 9 - 16 .
葛丹丹 , 金峰 , 樊文欣 . 筒形件强力旋压有限元数值模拟技术的研究 [J]. 热加工工艺 , 2011 , 40 ( 11 ): 93 - 95 .
封源 , 黎军顽 , 谢尘 , 等 . 铣刀深冷处理过程中残留奥氏体演变的数值模拟 [J]. 材料热处理学报 , 2014 , 35 ( S2 ): 230 - 235 .
杨 卿 . 基于环件热辗扩成形的铸态42CrMo钢热物理性能研究 [D]. 太原 : 太原科技大学 , 2013 .
Ma F , Yang H , Zhan M . Plastic deformation behaviors and their application in power spinning process of conical parts with transverse inner rib [J]. Journal of Materials Processing Technology , 2010 , 210 ( 1 ): 180 - 189 .
0
浏览量
0
下载量
0
CSCD
0
CNKI被引量
关联资源
相关文章
相关作者
相关机构
京公网安备11010802024621