1.中天钢铁集团(南通)有限公司炼钢厂,南通 226299
2.中冶南方工程技术有限公司炼钢分公司,武汉 430223
卢小辉(1978—),男,本科,高级工程师; E-mail: luxiaohui918@126.com
康从鹏(1993—),男,博士,工程师; E-mail: 03122@wisdri.com
收稿:2024-07-12,
纸质出版:2025-01-30
移动端阅览
卢小辉,康从鹏,陈洪智等.不同炉料条件下150 t AOD冶炼430不锈钢 物热平衡模拟[J].特殊钢,2025,46(01):134-139.
Lu Xiaohui,Kang Congpeng,Chen Hongzhi,et al.Simulation of Material and Heat Balance of 150 t AOD Melting 430 Stainless Steel under Different Charge Conditions[J].Special Steel,2025,46(01):134-139.
卢小辉,康从鹏,陈洪智等.不同炉料条件下150 t AOD冶炼430不锈钢 物热平衡模拟[J].特殊钢,2025,46(01):134-139. DOI: 10.20057/j.1003-8620.2024-00175.
Lu Xiaohui,Kang Congpeng,Chen Hongzhi,et al.Simulation of Material and Heat Balance of 150 t AOD Melting 430 Stainless Steel under Different Charge Conditions[J].Special Steel,2025,46(01):134-139. DOI: 10.20057/j.1003-8620.2024-00175.
为探究不同炉料条件对AOD冶炼不锈钢过程的影响,以150 t AOD炉冶炼430不锈钢作为例,基于实际的生产流程,构建了AOD精炼不锈钢过程的物料和热量平衡模拟系统。通过模拟计算,对不同炉料条件下的炉温变化以及相关的技术经济指标进行了深入的比较和分析。研究结果表明,采用脱磷铁水+固态铬铁的入炉原料条件会造成炉温偏低,在还原前期需加入大量硅铁合金补热以满足出钢要求。该工艺条件下,硅铁和石灰消耗量分别达到39.3、97.7 kg/t,高碳铬铁持续加入时间为12 min左右,加料速率为4 t/min,此时,最大供氧强度为400 m
3
/min。通过协调供氧量与加料速率之间的关系,以实现炉内温度的相对稳定;采用脱磷铁水+高铬铁水为入炉炉料条件下的工艺过程中,硅铁和石灰消耗量分别为25.7、58.9 kg/t,该工艺过程会产生热量富余,通过加入废钢作为冷却剂来控制炉温并满足出钢温度要求,该条件下吨钢废钢消耗量为169.1 kg,废钢加入量占比为15.1%。模型计算过程可以根据入炉原料条件调节并优化炉料配比,可为AOD生产不锈钢提供理论与生产指导。
In order to explore the influence of different charge conditions on the process of AOD smelting stainless steel, taking 430 stainless steel smelting in 150 t AOD furnace as an example, based on the actual production process, a material and heat balance simulation system of AOD refining stainless steel process was constructed. Through simulation calculation, the furnace temperature change under different charge conditions and related technical and economic indexes are deeply compared and analyzed.The results show that the furnace tempe
rature will be low by using the raw material condition of dephosphorized molten iron and solid ferrochromium, and a large amount of ferrosilicon alloy should be added in the early stage of reduction to meet the requirements of steel tapping. Under this process condition, the consumption of ferrosilicon and lime reached 39.3 kg/t and 97.7 kg/t respectively, the continuous addition time of high carbon ferrochromium was about 12 min, the feeding rate was 4 t/min, and the maximum oxygen supply intensity at this time was 400 m
3
·min
-1
. By coordinating the relationship between oxygen supply and feeding rate, the temperature in the furnace was relatively stable; In the process of using dephosphorized molten iron + high chromium molten iron as furnace charge, the consumption of ferrosilicon and lime was 25.7 kg/t and 58.9 kg/t respectively. This process would generate heat surplus. By adding scrap steel as coolant to control the furnace temperature and meet the tapping temperature requirements, under this condition, the consumption of scrap steel per ton of steel was 169.1 kg, and the proportion of scrap steel added was 15.1%. The model calculation process can adjust and optimize the charge ratio according to the conditions of raw materials entering the furnace, which can provide theoretical and production guidance for AOD production of stainless steel.
李天宝 . 现代铁素体不锈钢的性能及应用 [M]. 太原 : 山西科学技术出版社 , 2015 .
赵萍 . 400系不锈钢推广前景看好 [N]. 中国冶金报 , 2023 .
杜 鑫 , 龚 伟 , 姜周华 , 等 . 转炉+AOD两步法冶炼不锈钢物热平衡模型开发 [J]. 中国冶金 , 2023 , 33 ( 8 ): 84 - 91 .
王海江 , 李 实 . 120 tAOD全铁水冶炼 400系不锈钢数学模型的应用 [J]. 河北冶金 , 2019 ( 4 ): 48 - 52+67 .
叶凡新 , 冯文甫 , 郭志彬 , 等 . 60 t AOD全铁水精炼400系不锈钢热补偿技术的工艺实践 [J]. 特殊钢 , 2016 , 37 ( 6 ): 44 - 46 .
陈圣鹏 . 新原料条件下不锈钢冶炼工艺及物料平衡、热平衡模拟 [J]. 铁合金 , 2021 , 52 ( 6 ): 12 - 17 .
Patra S , Nayak J , Singhal L K , et al . Prediction of nitrogen content of steel melt during stainless steel making using AOD converter [J]. Steel Research International , 2017 , 88 ( 5 ): 1600271 .
孙铭山 , 邹 勇 , 范光伟 . AOD冶炼不锈钢氮合金化控制模型的研究和应用 [J]. 特殊钢 , 2008 , 29 ( 6 ): 7 - 9 .
Pitkälä J , Holappa L , Jokilaakso A . Nitrogen control in production of N-alloyed stainless steels in AOD converter: Application of sieverts’ law [J]. Metallurgical and Materials Transactions B , 2024 , 55 ( 1 ): 524 - 536 .
Wei J H , Cao Y , Zhu H L , et al . Mathematical modeling study on combined side and top blowing AOD refining process of stainless steel [J]. ISIJ International , 2011 , 51 ( 3 ): 365 - 374 .
王 哲 . 矿热炉与AOD炉双联法冶炼不锈钢的设计与研究 [D]. 西安 : 西安建筑科技大学 , 2009 .
Guan C J , You W . A nonlinear prediction model, incorporating mass transfer theory and expert rules, for refining low-carbon ferrochrome [J]. Journal of the Southern African Institute of Mining and Metallurgy , 2020 , 120 ( 12 ): 671 - 680 .
孙如意 , 卢征统 , 姬建民 , 等 . 缩短AOD炉冶炼300系不锈钢周期的探讨 [J]. 铁合金 , 2024 , 55 ( 1 ): 36 - 38 .
王恭一 , 赵惠忠 , 黄日清 , 等 . AOD炉渣对镁钙质耐火材料的侵蚀机理 [J]. 硅酸盐通报 , 2023 , 42 ( 4 ): 1496 - 1505 .
卢嘉枫 , 李 晶 , 史成斌 , 等 . 304不锈钢AOD冶炼过程脱碳保铬和铬烧损的研究 [J]. 江西冶金 , 2021 , 41 ( 1 ): 12 - 18 .
易天龙 , 吴华杰 , 孙悦 , 等 . AOD精炼双相不锈钢2101去碳保铬研究 [J]. 工程科学学报 , 2020 , 42 ( S1 ): 89 - 94 .
0
浏览量
1
下载量
0
CSCD
0
CNKI被引量
关联资源
相关文章
相关作者
相关机构
京公网安备11010802024621