1.大冶特殊钢有限公司,黄石 435001
2.中信特钢研究院,江阴 214400
刘文学(1973—),男,硕士,高级经济师;E-mail:liuwenxue@citicateel.com
收稿:2025-03-12,
纸质出版:2025-05-30
移动端阅览
刘文学,刘光辉,李林森等.真空自耗重熔电弧稳定性的影响因素与工艺控制[J].特殊钢,2025,46(03):12-17.
Liu Wenxue,Liu Guanghui,Li Linsen,et al.Influencing Factors and Process Control of Vacuum Consumable Remelting Arc Stability[J].Special Steel,2025,46(03):12-17.
刘文学,刘光辉,李林森等.真空自耗重熔电弧稳定性的影响因素与工艺控制[J].特殊钢,2025,46(03):12-17. DOI: 10.20057/j.1003-8620.2025-00065.
Liu Wenxue,Liu Guanghui,Li Linsen,et al.Influencing Factors and Process Control of Vacuum Consumable Remelting Arc Stability[J].Special Steel,2025,46(03):12-17. DOI: 10.20057/j.1003-8620.2025-00065.
通过研究真空自耗重熔高温合金和特种不锈钢过程中极间电弧的行为变化,分析了电极尺寸、外部质量、气体含量等因素对电弧与熔炼稳定性的影响。结果表明,电极直径偏差较大时,明显影响料杆移动速度计算,从而异常地调节电弧间隙,出现短路、熔滴频率偏离等工况,应控制其锥度≤0.5%;电极上的裂纹和缩孔缺陷干扰电弧稳定控制,尤其横裂纹导致熔滴和熔速严重失稳;母材氮含量较高时气体溢出显著,会引起电弧偏移,熔滴、气氛压力波动。因此,电极制备时控制
w
[N]≤0.003%为宜;不同炉台存在明显设备差异性,应针对性探索合适的PID控制参数。
The behaviors of interelectrode arc during vacuum arc remelting of high-temperature alloy and special stainless steel were investigated in this paper, and the influence factors such as electrode size, external quality, and gas element content on arc stability were analyzed. The results showed that large deviation of electrode diameter significantly affected the calculation of rod base speed, resulting in abnormal adjustment of arc gap, short circuits, and deviation of droplet frequency. The electrode taper should be controlled to be ≤0.5%. Cracks and shrinkage cavities defect on the electrode interfered with arc stability control, especially radial cracks leading to severe instability of droplets and remelting rates. Gas overflow was significant with high nitrogen in base material, which caused arc deviation, fluctuations in droplet and atmosphere pressure. Therefore, it is advisable to control
w
[N]≤0.003% during electrode preparation. There were obvious differences in equipment among different furnaces, and appropriate PID parameters should be explored.
李俊杰 , 李盼悦 , 黄立清 , 等 . 真空自耗电弧熔炼铸锭凝固行为多尺度模拟研究进展 [J]. 金属学报 , 2025 , 61 ( 1 ): 12 - 28 .
孙成仁 , 吴晓强 . 真空自耗电弧炉熔滴控制研究 [J]. 科学家 , 2017 , 5 ( 16 ): 174 - 175 .
陈国胜 , 刘丰军 , 王庆增 , 等 . GH4169合金VIM+PESR+VAR三联冶炼工艺及其冶金质量 [J]. 宝钢技术 , 2012 , 5 ( 1 ): 6 - 10 .
张晶宇 , 范丽娟 , 张一鹏 , 等 . 影响真空自耗电极电弧炉电弧稳定性的因素及对策 [J]. 真空 , 2003 , 40 ( 3 ): 21 - 24 .
任 伟 , 唐佳佳 , 胡 玲 , 等 . 真空电弧重熔炉钢锭断面形状与电气控制的关系探讨 [J]. 工程技术研究 , 2017 , 2 ( 3 ): 109 - 110 .
邹武装 . 钛及钛合金真空自耗熔炼过程中关键参数控制分析 [J]. 钛工业进展 , 2011 , 28 ( 5 ): 41 - 44 .
杨永维 , 陈今润 , 纪亚芳 . 基于PLC的真空自耗电弧炉控制系统 [J]. 自动化技术与应用 , 2008 , 27 ( 5 ): 50 - 53 .
杨玉军 , 赵长虹 , 李爱民 , 等 . 高温合金真空自耗重熔的工艺控制 [C]. 动力与能源用高温结构材料——第十一届中国高温合金年会论文集 . 北京 , 2007 : 17 - 19 .
王小川 , 王佳明 . 浅议真空电弧炉重熔含氮钢的过程控制 [J]. 特钢技术 , 2021 , 27 ( 3 ): 16 - 19 .
陈庆红 , 徐世珍 , 蒋晓东 . 真空自耗电弧熔炼过程电弧及熔滴热传输行为的数值模拟 [C]// 2013海峡两岸功能材料科技与产业峰会论文集 . 2013 : 30 - 33 .
0
浏览量
4
下载量
0
CSCD
0
CNKI被引量
关联资源
相关文章
相关作者
相关机构
京公网安备11010802024621