镁处理对430铁素体不锈钢夹杂物形成和凝固组织的影响

特殊钢 ›› 2013, Vol. 34 ›› Issue (2): 48-51.

镁处理对430铁素体不锈钢夹杂物形成和凝固组织的影响

公茂涛^1,2，陈兆平²，徐迎铁²，疏达¹

1上海交通大学金属基复合材料国家重点实验室，上海 200240；
2宝山钢铁股份有限公司研究院，上海 201900；

收稿日期:2012-10-10 出版日期:2013-04-01 发布日期:2022-10-08
作者简介:公茂涛(1987-)，男，硕士研究生，铁素体不锈钢凝固组织研究。

Effect of Magnesium Treatment on Inclusion Formation and Solidification Structure Ferrite Stainless Steel 430

Gong Maotao^1,2，Chen Zhaoping²，Xu Yingtie²，Shu Da¹

1 State Key Laboratory of Metal Matrix Composite, Shanghai Jiaotong University, Shanghai 200240；
2 Research Institute t Baoshan Iron and Steel Co Ltd, Shanghai 201900

Received:2012-10-10 Published:2013-04-01 Online:2022-10-08

摘要/Abstract

摘要： 试验研究了0.000 5%～0.001 2%Mg对60 kg真空感应炉熔炼的430铁素体不锈钢(/%:0.04C、0.25～0.32Si、0.28～0.38Mn、16.5～16.9Cr)夹杂物形成和凝固组织的影响。结果表明,430钢液中添加镁合金后,钢中形成平均粒径更小,数量密度更大的含MgO复合夹杂物;镁合金的加入可以改善430钢的凝固组织,且浇铸温度越低,改善效果越明显,在1 580℃浇铸时,等轴晶率由常规钢的30.8%提高至镁处理钢的88.5%,相应等轴晶尺寸由1 741.6μm降至945.3μm。含MgO夹杂物与δ相二维错配度极小,可作为430钢有效异质形核剂,促进等轴晶的形成,抑制柱状晶的生长,细化凝固组织。

关键词: 430铁素体不锈钢, 镁处理, 夹杂物, 凝固组织

Abstract: The effect of 0. 000 5% ~Q. 001 2% Mg on inclusion formation and solidification structure of ferrite stainless steel 430 (/% : 0.04C, 0.25-0.32Si, 0.28-0.38Mn, 16.5-16.9Cr) melting by a 60 kg vacuum induction furnace has been tested and studied. Results show that with adding magnesium alloy in liquid steel 430 the size of MgO compound inclusions in steel decreases while their number and density are increase； adding magnesium alloy is available io improve the solidification structure of steel 430 and the lower the casting temperature the more obvious the improved effect, for instance with casting at 1 580 ℃ the equiaxed zone ratio of magnesium-treated steel increases to 88.5% from 30.8% of non-treated normal steel while the correspondent equiaxed grain size decreases to 945.3 μm from 1741.6 μm. The planar dis-registry between inclusions containing MgO and δ phase is minor, it is an effective heterogeneous nucleation agent to promote the formation of equiaxed crystal and inhibit the growth of columnar crystal, finally fine the solidification structure of casting steel 430.

公茂涛, 陈兆平, 徐迎铁, 疏达. 镁处理对430铁素体不锈钢夹杂物形成和凝固组织的影响[J]. 特殊钢, 2013, 34(2): 48-51.

Gong Maotao, Chen Zhaoping, Xu Yingtie, Shu Da. Effect of Magnesium Treatment on Inclusion Formation and Solidification Structure Ferrite Stainless Steel 430[J]. Special Steel, 2013, 34(2): 48-51.

参考文献

[1] Hamada J, Matsumoto Y, Fudanoki F. Effect of Initial Solidified Structure on Ridging Phenomenon and Texture in Type 430 Ferritic Stainless Steel Sheets[J]. ISIJ International12003 ,43 (12)：1989-1998.
[2]施晓芳，成国光，赵沛.钛改善430铁素体不锈钢凝固组织的研究[J].中国稀土学报,2010,28(增刊)：396-399.
[3]成国光，朱晓霞，彭岩峰，等.洁净钢氮化钛凝固细化技术的基础[J] .北京科技大学学报,2002,24(3):273-279.
[4]Shan Y, Luo X, Hu X, et al. Mechanism of Solidification Structure Improvement of Ultra-Pure 17wt%Cr Ferritic Stainless Steel by Ti, Nb,Addtion[J]. J. Mater. Sei, Technol,2011,27(4)：352-358.
[5]Kim H S, Chang C, Lee H. Evolution of Inclusions and Resultant Microstructural Change With Mg Addition in Mn/Si/Ti Deoxidized Steels[J]. Scripta Materialia,2005 ,53 ： 1253-1258.
[6]孙文山，丁桂荣、罗铭蔚，等.35CrNi3MoV钢液镁处理的效果[J].钢铁,1997,32(10):662-665.
[7] Fu J, Yu Y, Wang A, et al. Inclusion Modification With Mg Treatment for 35CrNi3MoV Steel [J]. J. Mater. Sci. Technol, 1998,14: 53-56.
[8] Isobe K. Effect of Mg Addition on Solidification Structure of Low Carbon Steelf J]. ISU International,2010,50(12):1972-1980.
[9] DoHoff R T. Quantitative Microscopy. New York, NY : Mc-Graw-Hill, 1968:128.
[10] Kimura S,Nakajima K,Mizoguchi S. Behavior of Alumina-magnesia Complex Inclusions and Magnesia Inclusions on the Surface of Molten Low-carbon Steels[J]. Metallurgical and Materials Transactions B,2001,32(2) ：79-85.
[11] Kurz W,Fisher D J.凝固原理[M].李建国，胡侨丹译.北京:高等教育出版社,2010：22.
[12] Bramfitt B L. The Effect of Carbide and Nitride Additions on the Heterogeneous Nucleation Behavior of Liquid Iron[J], Metallurgical Transactions, 1970,1(7): 1987-1995.
[13] Fiquet G, Richet P, Montagnac G. H i gh - temperature Thermal Expansion of Lime, Periclase, Corundum and Spinel [J], Phys Chem Minerals,1999,27(2) ：103-lll.
[14] Fletcher N H. Size Effect in Heterogeneous Nucleation [J]. The Journal of Chemical Physics ,1958,29(3) ：572-576.
[15] Hunt J D. Steady State Columnar and Equiaxed Growth of Dendrites and Eutectic] J]. Materials Science and Engineering, 1984,65 ：75-83.