温度对33EH高性能烧结钗铁硼永磁体磁性能的影响

特殊钢 ›› 2015, Vol. 36 ›› Issue (1): 45-48.

温度对33EH高性能烧结钗铁硼永磁体磁性能的影响

王凌燕，于旭光，张翼，刘丹，王俊帅

石家庄铁道大学，河北省交通工程材料重点实验室，石家庄050043

收稿日期:2014-08-05 出版日期:2015-02-01 发布日期:2022-08-30
作者简介:王凌燕(1989-),女，硕士研究生(石家庄铁道大学),2012年石家庄铁道大学四方学院(本科)毕业，磁性材料及应用研究。
基金资助:
河北省自然科学基金重点项目资助(E2012210009),

及河北省高校重点学科建设项目资助。

Effect of Temperature on Magnetic Performance of 33EH High Quality Sintered NdFeB Permanent Magnets

Wang Lingyan, Yu Xuguang, Zhang Yi, Liu Dan and Wang Junshuai

Hebei Provincial Key Laboratory of Traffic Engineering Materials, Shijiazhuang Tiedao University, Shijiazhuang 050043

Received:2014-08-05 Published:2015-02-01 Online:2022-08-30

摘要/Abstract

摘要： 试验研究了温度(25~200℃)对33EH烧结钕铁硼(/%:27.01 Nd,64.75Fe,0.35Al,3.15Dy,1.56Co,2.27Cu,0.90Ga)剩磁、磁感损失等参数的影响。结果表明,随温度升高剩磁呈线性降低,100℃时剩磁下降7.6%,200℃时剩磁下降22%。25~100℃时,随温度升高开路磁感损失约1%,100~200℃,随温度升高,开路磁感损失急剧增加,至200℃时,开路磁感损失达44%,33EH烧结钕铁硼最佳使用温度为≤100℃。

关键词: 33EH, 烧结钕铁硼永磁体, 磁性能, 服役温度

Abstract: The effect of temperature (25 〜200 ℃) on magnetic performance of 33EH sintered NdFeB (/% ：
27. 01 Nd, 64. 75Fe, 0. 35Al, 3. 15Dy, 1. 56Co, 2. 27Cu, 0. 90Ga) including residual magnet and magnet loss etc. has been tested and studied. Test results show that with increasing temperature, the residual magnet decreases linearly, at 100℃; the residual magnet decreases by 7. 6% and at 200 X. the residual magnet decreases by 22%. At 25 - 100 °C with increasing the temperature, the open-circuit magnet decreases by about 1%, at 100 ~ 200℃ with increasing the temperature, the open-circuit magnet loss increases dramatically, at 200 ℃ the open-circuit magnet decreases by 44%. The optimum service temperature of 33EH sintered NdFeB permanent magnets is ≤100 °C.

王凌燕, 于旭光, 张翼, 刘丹, 王俊帅. 温度对33EH高性能烧结钗铁硼永磁体磁性能的影响[J]. 特殊钢, 2015, 36(1): 45-48.

Wang Lingyan, Yu Xuguang, Zhang Yi, Liu Dan, Wang Junshuai. Effect of Temperature on Magnetic Performance of 33EH High Quality Sintered NdFeB Permanent Magnets[J]. Special Steel, 2015, 36(1): 45-48.

参考文献

[1]陈俊峰.永磁电机基础[M].北京:机械工业出版社,1982.
[2] Cullity B D. Introduction to Magnetic Materials [M]. Philippines: Addison-Wesley Company, 1972.
[3]唐任远.现代永磁电机理论与设计[M].北京:机械工业出版社，1997.
[4] Chen C H, Talangi J. The Effects of Neutron on NdFeB and Sm2Col7-based High-temperature Magnets] J]. IEEE Transactions on Magnetics,2005,41 (10):3832.
[5] Yang L,Zhen L,Xu C Y,et al. Effects of Proton Irradiation on Structure of NdFeB Permanent Magnets Studied by X-ray Diffraction and X-ray Absorption Fine Structure [J]. Journal of Magnetism and Magnetic Materials,2011,323 ：4-6.
[6]周寿增，董清飞,高学绪.烧结铉铁硼稀土永磁材料与技术[M]. 北京:冶金工业出版社,2011.
[7]于旭光，刘亮，秦茶，等.烧结机缝隙磁场密封模拟实验 [J].特殊钢,2009,30(2) ：25-26.
[8] Fang Y K, Yang Li, Zhen L, et al. Magnetic Micro-structures of a High Coercivity Nd-Fe-B Sintered Magnet in Remanent and Incomplete Thermal Demagnetization States [J]. Journal of Magnetism and Magnetic Materials,2010,322；3720-3723.
[9]李家节，李安华,朱明刚，等.烧结Nd-Fe-B磁体的环境稳定性研究进展[J].中国稀土学报,2011,29(1)：1-7.
[10]甄良，易忠，杨丽，等.不同尺寸的NdFeB稀土永磁体热退磁行为研究[J] .中国稀土学报,2013,31(1) ：26-30.
[11]白书欣，李顺，张虹，等.稀土永磁材料在风力发电机中的应用[C].山东:第四届全国高新磁性材料及器件讨论会论文集,2009：1-7.
[12]肖海航，曹宁，张辉.永磁材料及其在风电永磁发电机上的应用[J]东方电机,2009,37(1):3743.
[13]GB/T13560-2009.烧结铉铁硼永磁材料[S].北京：中国标准出版社,2009.
[14]全国磁学计量技术委员会.JJF1239-2010.稀土永磁材料磁性温度系数测量技术规范[S].北京:中国计量出版社,2010.
[15]郭策安，张健,林常海.超高矫顽力Nd-Fe-B永磁体的温度稳定性研究[J].沈阳理工大学学报,2008,27(1) ：77-79.
[16]中国国家标准化管理委员会.GB/T24270-2009.永磁材料磁性能温度系数测量方法[S].北京:中国标准出版社,2009.
[17]金瑞湘，陈敏勤，朱华，等.烧结钗铁硼永磁材料的热稳定性[J]电工材料,1991(3):19-24.
[18]于旭光，张增强，丁占来.冷处理对烧结钗铁硼磁性能的影响[J].石家庄铁道学院学报,2007,20(2):5-7.