Effect of Inner Structure of Tundish on Cleanliness of Casting Bloom

唐海燕; 李京社; 包燕平; 蒋静; 李涛; 吉传波

您当前的位置：

首页 >

文章列表页 >

Effect of Inner Structure of Tundish on Cleanliness of Casting Bloom

更新时间：2026-01-21

- Effect of Inner Structure of Tundish on Cleanliness of Casting Bloom
- Special Steel Vol. 30, Issue 6, Pages: 17-19(2009)
- 作者机构：
  
  北京科技大学冶金与生态工程学院,北京,100083
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Received：12 May 2009，
  
  Online First：14 November 2022，
  
  Published：14 November 2009
- 稿件说明：
移动端阅览
唐海燕, 李京社, 包燕平, et al. Effect of Inner Structure of Tundish on Cleanliness of Casting Bloom[J]. Special Steel, 2009, 30(6): 17-19.
DOI：

唐海燕, 李京社, 包燕平, et al. Effect of Inner Structure of Tundish on Cleanliness of Casting Bloom[J]. Special Steel, 2009, 30(6): 17-19. DOI：

摘要

通过1:2.5中间包水模型试验对4流25 t两种控制装置中间包内流场进行了研究

并通过工业生产试验了原中间包和改变挡墙侧导流孔孔径、倾角

并增加湍流控制的改进型中间包对325mm×280 mm GCr15钢铸坯洁净度的影响。结果表明

改进型中间包能增加钢液在中间包内的停留时间

减小中间包的死区比例

提高夹杂物的去除率。与原中间包相比

从改进型中间包到铸坯过程钢中总氧去除率提高

大型夹杂物含量降低44.9%。

Abstract

A study on the field of fluid flow in 4-strand 25 t tundish with two different control devices has been carried out by 1 ： 2. 5 tundish water model test. And the effect of original tundish and improved tundish with modified diameter of hole for guide fluid at side of dam and its inclination

and added turbulent inhibitor on cleanliness of 325 mm x 280 mm casting bloom of bearing steel GCrl5 is tested by commercial production. Results show that the improved tundish is available to increase residence time of liquid steel in tundish

decrease dead volume fraction of tundish

increase removal rate of inclusion in liquid. Compared with the original tundish

the removal rate of total oxygen in liquid steel from improved tundish to bloom increases

the macro-inclusion content decreases by 44. 9% .

关键词

Keywords

references

Views

下载量

CSCD

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation of Influence of Flow Control Device on Transfer Performance in Tundish for H-Beam Bloom Casting with Speed 0.8 m/min

Effect of Refining Slag Basicity on the Molten Steel Cleanliness of GCr15SiMn Bearing Steel

Effect of Adding Direct Reduced Iron to EAF on Steelmaking

Effect of Current on the Cleanliness of Electroslag Ingots During Low Frequency Electroslag Remelting

Effect of La-Ce Rare Earth on Inclusions and Impact Properties of Q345D Steel

Related Author

阮飞

张红强

刘智宇

冯帅

白亮

Guo Yunfei

Qiu Mian

Chen Gang

Related Institution

内蒙古科技大学材料与冶金学院

天津钢管集团技术中心

上海大学省部共建高品质特殊钢冶金与制备国家重点实验室

State Key Laboratory of Advanced Metallurgy， University of Science and Technology Beijing

State Key Laboratory of Intelligent Mining Equipment Technology

⁰