Field Synergy Analysis and Fluid Flow Optimization of Tundish for Six Strands

Special Steel ›› 2009, Vol. 30 ›› Issue (4): 1-4.

Field Synergy Analysis and Fluid Flow Optimization of Tundish for Six Strands

Zhang Meijie^1,2, Lin Xiaolong¹, Huang Ao¹, Wang Houzhi¹，Gu Huazhi¹

1 Hubei Province Key Lab of Refractories and Ceramics, Wuhan University of Science and Technology, Wuhan 430081 ；
2 Key Lab for Thermal Science and Power Engineering of Ministry of Education,School of Aerospace, Tsinghua University, Beijing 100084

Received:2009-02-20 Online:2009-08-01 Published:2022-12-14

六流中间包场协同分析及流场优化

张美杰^1,2，林小龙¹，黄奥¹，汪厚植¹，顾华志¹

1武汉科技大学，耐火材料与高温陶瓷重点实验室-省部共建国家重点实验室培育基地，武汉430081；
2清华大学航天航空学院，热科学与动力工程教育部重点实验室，北京100084

作者简介:张美杰(1972-),女，博士，副教授，武汉科技大学毕业，工业炉内流场仿真模拟和优化，窑炉设计和改造。
基金资助:
国家科技攻关计划项目资助(2005BA325C)；973计划前期研究专项资助(2009CB626605)

Abstract

Abstract: The relation between distribution of temperature and fluid flow field in tundish for concasting has been analyzed by using theory of field synergy and the distribution of temperature and fluid flow field in a tundish for six strands at a steel works was simulated and numerically calculated. Results showed that as tundish without flow control devices, the synergy between temperature gradient field and fluid flow field was better, the temperature gradient of liquid steel was great i. e. the max temperature differential - 27 K and the max temperature differential at outlet - 3 K with large entrancy dissipation value and large difference between curves of residence time distribution at outlet； as tundish with baffles, the degree of synergy between temperature gradient field and fluid flow field decreased, the distribution of liquid steel was even i. e. the max temperature differential - 12 K and the max temperature differential at outlet - only 0. 3 K, the value of entrancy dissipation decreased by 57. 6% and the curves of residence time distribution at outlet were similar.

摘要： 采用场协同理论分析了连铸中间包内钢液流场与温度分布之间的关系,并对钢厂六流中间包进行了数值模拟计算。结果表明,当中间包不采用控流装置时,大部分区域钢液流场与温度梯度场协同性好,钢液温度梯度大,最大温差达27 K,出口最大温差达3 K,(火积)耗散值大,各出口RTD(停留时间分布)曲线相差较大;当中间包内设置斜孔挡墙后,钢液流场与温度梯度场间的协同程度降低,钢液温度分布较均匀,最大温差为12 K,各出口最大温差仅为0.3 K,(火积)耗散值降低了57.6%,各出口RTD曲线近似。

关键词: 中间包, 场协同, 流场优化

Zhang Meijie, Lin Xiaolong, Huang Ao, Wang Houzhi , Gu Huazhi. Field Synergy Analysis and Fluid Flow Optimization of Tundish for Six Strands[J]. Special Steel, 2009, 30(4): 1-4.

张美杰, 林小龙, 黄奥, 汪厚植, 顾华志. 六流中间包场协同分析及流场优化[J]. 特殊钢, 2009, 30(4): 1-4.